After years of breaking down ice, it stripped the hexagon key in the motor, and would just spin under load. The gear box turns very slowly but has lots of power to push the ice. Press MAX ICE again to turn the feature off. To remove the ice bucket, lift up the bin and pull it out of the freezer. Thanks Blue is 3.3. The Auger would turn with a few ice cubes in the bin, but not under load. I did download the owners manual and the parts diagrams for this unit, but cannot find a service manual that might help me figure this out. Carefully guide your new ice maker bucket in around the auger spiral until it can set into the housing. DO NOT ATTEMPT THIS KIND OF REPAIR UNLESS YOU ARE COMFORTABLE WITH WIRING … It is the drive off the motor that is not engaging. • I took the dispenser motor out and applied electrical current to it and it works fine also. Ice maker auger will dispense cubes, when the auger reverses for crushed ice it stops, you can hear the motor running. Options. An ice maker auger is the spiral-shaped part located in the ice maker bucket. If the auger is not turning you should first verify the motor is operating. the ice maker is put ON on the control panner. Again, ice is filled in the freezer ice maker!!!! thinking that would be all that was needed. Welcome Guest! Model: KSRT25CRWH01: Brand: Kitchen Aid: Age: 1 - 5 years: Previous Topic Next Topic: bobmc11 #1 Posted : Friday, November 21, 2008 4:33:05 PM(UTC) Rank: Member. If the ice maker is getting water but not ejecting into the ice bin that would be an issue with the ice maker motor. Auger drive will not turn by: Tye The plastic auger in the ice box turns fine. The rod that turns the auger is a hexagon shaped piece, much like a screw driver you would use with your drill. Or is it possible that there is some kind of a lever/interlock that is not made up properly that could cause this. ... Whirlpool ice maker making knocking noise, but still makes ice. I have tried turning the ice maker on and off and no change. If the auger turns freely, use a multimeter to test the auger motor for continuity. If the auger motor is burned out or defective, the ice won’t move forward and fall through the chute. WHIRLPOOL Ice bucket coupling (WP2188918) $21.82: Do-It-Yourself Stories from Customers like You . To determine... if the auger motor is defective, pull out the ice bucket and turn the bucket auger by hand. Completing the CAPTCHA proves you are a human and gives you temporary access to the web property. Total Satisfaction Rating (117) View All Do-It-Yourself Stories Have questions? If your KitchenAid Ice Maker is not working use this troubleshooting guide to diagnose common problems. Check to ensure your ice maker is level. I have a Whirlpool ice dispenser that will not turn the auger to dispense the ice. The blades of the ice dispenser drum had both broken, so the spindle rotated freely inside the drum. Parts for Whirlpool ED2KHAXVS03 .
If the control board is faulty, it may stop supplying power to the entire dispenser system. Appliance: Whirlpool Refrigerator ED2KHAXVT01 My Repair & Advice. While trying to dispense ice cubes, switching over to crushed ice, ice stopped dispensing and will not dispense either crushed or cube. Could it be auger motor is not working? Groups: Registered Joined: 11/21/2008(UTC) Posts: 2. If the auger is not turning you should first verify the motor is operating. Ice bucket/crushing motor would run but ice auger wasn't turning Kenneth C. • Massapequa Park, NY • September 19, 2014. If you are on a personal connection, like at home, you can run an anti-virus scan on your device to make sure it is not infected with malware. ... Only clean your ice maker according to the directions in the user manual and be sure to unplug your refrigerator or turn off the circuit breaker that supplies power to the appliance before beginning this cleaning task. Joined Jun 16, 2015 Messages 2 Location United States. Manufactured by Whirlpool. Plug in the ice maker or reconnect power. Clear any obstructions found. • The auger is driven by a motor mounted behind the bin with a set of drive forks on the gear box shaft. Immediately after the stoppage occured could smell electrical/electronic burn/melt odor. Whirlpool mode ED5VHEXV006 ... Makes ice but won't dispense because auger won't turn. If the dispenser door solenoid does not have continuity, or if the actuator pin does not move freely, replace the d... Glass Tray, Coupler & Support Roller Parts. There could be several reasons that your ice maker auger is not working. I have tried turning the ice maker on and off and no change. If the auger motor is burned out or defective, the ice won’t move forward and fall through the chute. Use a nut driver to remove the screws holding the auger motor to the back of the freezer. Make sure that the ice bucket is inserted properly into the freezer so that the auger motor arms properly spin the auger. The auger … Ice maker stopped dispensing ice from the door. To determine if the auger motor is defective, pull out the ice bucket and turn the bucket auger by hand. I am assuming that the motor should turn the auger. Auger Drive Failure - With the ice bucket removed, depress the dispensing lever (where you place a glass to fill with ice) and the door switch (inside the freezer) at the same time, and visually observe the shaft from the motor that drives the auger (located just below the ice bucket position), to ensure it’s turning. With the ice box out I depress the door switch and the paddle the switch on the ice maker that opens the chute for the ice goes up but the drive that turns the auger will not spin. The click noise is the ice door opening but no ice comes out since the auger isn't turning. If it’s still on or jammed, continue reading. Another way to prevent getting this page in the future is to use Privacy Pass. Cause #1 Ice Door Kit - 31% of the time Total Satisfaction Rating (173) Ice Door Kit for Whirlpool ED2KHAXVS03 Ice maker won't dispense ice. Water dispenser still works, as well as making ice. To determine if the auger motor is defective, pull out the ice bucket and turn the bucket auger by hand. If the auger turns freely, use a multimeter to test the auger motor for continuity. This switch also allows the ice maker to dispense ice through the door, disengaging the dispenser when the door is open. You should see the auger turning as the motor runs. If you are at an office or shared network, you can ask the network administrator to run a scan across the network looking for misconfigured or infected devices. Groups: Registered Joined: 9/6/2010(UTC) Posts: 5. I fixed it by getting a Samsung refrigerator. I have check and the cylanoid is working ok. Unplug your refrigerator from the wall outlet behind it. I have removed the ice box and the ice maker, let it thaw and put back in and still nothing but noise. Tighten the screws firmly to ensure the bucket does not come loose later when it’s full of ice. So, if your ED2KHAXVS03 refrigerator ice maker dispenser not working, ice maker makes ice but won't dispense or Ice maker not dispensing ice, the following info will help you identify the problem. I can't figure out how to remove it. I have this fridge and the ice maker works but the auger doesn't advance the ice nor does it crush (or maybe it does but since the auger isn't advancing the ice, there's nothing to crush). This motor rotates the auger. Our ice maker model had a one-piece drum & auger, so I ordered both parts of the two-piece replacement set. I have searched and searched for a service manual for the refridgerator and/or the ice maker and cannot find one. Our ice maker model had a one-piece drum & auger, so I ordered both parts of the two-piece replacement set. Immediately after the stoppage occured could smell electrical/electronic burn/melt odor. If the auger motor is burned out or defective, the ice won’t move forward and fall through the chute. Jun 16, 2015 #1 Model Number MSD2574VEM11 Brand Maytag Age 1-5 years I went to get ice this morning out of the ice dispenser on my Maytag fridge and after I was done the ice continued to pour out of the door. Whirlpool GD5rvaxvy05 approx 10 - Answered by a verified Appliance Technician. Kenmore(###) ###-####.703. To enable all features please, YAF.NET © 2003-2020, Yet Another Forum.NET. Hope this helps! The electronic door opened and the motor would come on with a repeated clicking noise. Can you help? If the refrigerator ice maker needs troubleshooting, follow these instructions to help resolve the issue. Ice maker auger will not turn off! By chatting … If the motor runs but the auger does not turn, check for obstructions in the auger such as it being frozen to the ice bucket. If the dispenser door solenoid does not have continuity, or if the actuator pin does not move freely, replace the d... Glass Tray, Coupler & Support Roller Parts. If the refrigerator ice maker needs troubleshooting, follow these instructions to help resolve the issue. The driveshaft end that fits into the motor is slightly rounded but still seems like there are enough ridges to secure it. I disassembled my ice maker in my 2002 whirlpool model ED5FHEXLQ00 side by side refridgerator yesterday to fix a problem with the ice not ejecting from the tray, and when I put everything back together, the ice maker now makes ice properly, but now won't dispense. When I actuate the dispenser lever, the solenoid for the motor picks up and the chute opens up like it should, but the motor will not turn. Make sure that the ice bucket is inserted properly into the freezer so that the auger motor arms properly spin the auger. I have the motor out, how do I test it. The solenoid pulls the ice crusher up but the auger will not turn even after replacing motor. Screw Into the Assembly Housing; Settle the new ice bucket into the assembly housing and retrieve the screws you just removed. Thread starter Upsfeederdude; Start date Jun 16, 2015; U. Upsfeederdude Premium Member. Use a nut driver to remove the screws holding the auger motor to the back of the freezer. Thanks for any help, Ken . Depending your brand and model, you will turn off a switch on the body of the ice maker, on the wall of the freezer or lift the metal arm on the ice maker… The bucket is full of fresh ice; we emptied it completely and allowed fresh ice to fill the bucket Water dispenser still works, as well as making ice. When ice has formed and it's ready to leave the bucket, the auger rotates to move it forward. It is the drive off the motor that is not engaging. Ice would basically have to fall through the hole by chance even though the auger was turning.
If the control board is faulty, it may stop supplying power to the entire dispenser system. I think the nut has broken loose from the coupling bracket. It is almost impossible to get … however the lever does not move to dispense the ice out of the hole on the freezer door When I push the dispenser I hear a click. It is still making ice, but the noise is irritating. I thought for sure it was the motor and replaced it. I simulate the door being closed by pushing the door button in. If the auger motor is burned out or defective, the ice won’t move forward and fall through the chute. Whirlpool refrigerator ice maker auger fixing a broken ice dispenser in how to test if auger motors are working whirlpool french door refrigerator not. The Auger would turn with a few ice cubes in the bin, but not under load. I have a Whirlpool GS6NBEXRS01 fridge the ice maker makes ice, but doesn't dispense. Also found bits of white plastic in the ice just before it stopped working. In a nutshell, the coupling on the motor driven shaft for the ice maker is not turning the auger to force ice out. however the lever does not move to dispense the ice out of the hole on the freezer door When I push the dispenser I hear a click. Also, once the ice maker has dropped a load ice, it is ready for to make new ice and it should then fill with water. Their filter selection tool will help you identify the right filter for your refrigerator or icemaker. I have 120Vac all the time between gray and ground. The auger in your Whirlpool refrigerator model ... Raise up the ice arm to turn off the ice maker. You may need to download version 2.0 now from the Chrome Web Store. If it’s still on or jammed, continue reading. Dispenser (on door) will not eject any ice from bin. All electrical parts work and nothing is stuck. With the ice box out I depress the door switch and the paddle the switch on the ice maker that opens the chute for the ice goes up but the drive that turns the auger will not spin. AppliancePartsPros.com » Appliance Repair Help » Refrigerator & Freezer Repair » Ice Maker Auger Does Not Turn. The bucket is full of fresh ice; we emptied it completely and allowed fresh ice to fill the bucket It sounds like the dispenser engages but does not move the ice and the flap does open. Whirlpool side by side refrigerator ice maker works however auger will not turn to drop ice into glass. This video provides step-by-step repair instructions for replacing the ice bucket auger on a Whirlpool refrigerator. There's no noise. The auger in your Whirlpool refrigerator model ... Raise up the ice arm to turn off the ice maker. To remove the ice bucket, lift up the bin and pull it out of the freezer. By continuing to use this site you consent to the use of cookies on your device as described in our cookie policy unless you have disabled them. The auger motor spins the auger blade and pushes the ice through the dispenser chute. I defrosted the ice tray and refilled it with made ice to no avail. If the auger is not turning… Cloudflare Ray ID: 5fa8ead04d87e66c Our ice maker model had a one-piece drum & auger, so I ordered both parts of the two-piece replacement set. Ordered a Refrigerator Auger - 2196296 . If the freezer temperature is above 10 degrees Fahrenheit (-12C), the ice maker will not produce ice cubes efficiently. Ask our pros! My ice maker dispenser is not working. The unit dispenses water, but will not dispense ice. The ice trap door opens properly, the light on the touch pad display comes on when you select Ice, the unit makes ice, but the auger does not turn on. Everything else within the ice cube maker seems to be working (making ice … They came with everything needed to complete the repair. Ask Question Asked 3 years, 8 months ago. auger not moving by: Anonymous I have a gss25sgress and I just got it from a friend because the ice maker will not dispence ice. After ruling out a clogged chute, I figured that the motor was stripped. When researching this I was mostly lead down the path to replace the ice maker - thinking the electronics where keeping the auger from turning and dispensing ice but eventually I ran across these other part options and read that the auger might not be operational due to the ice maker lever in the door not depressing the auger engage button. If the ice maker is making ice, and the ice bin is full and the ice isn’t frozen together, when you press your cup for ice, a switch will click and the auger motor should start turning. 1. Their filter selection tool will help you identify the right filter for your refrigerator or icemaker. The motor/gear box normally makes enough noise that you can hear it with the freezer door closed. The ice maker works fine and the ejector works when I manually advance the ice but I would guess the motor for the auger is bad. Whirlpool Model: ED0GTQXKQ00 Appliance Serial: SL35488828. Once the ice bucket assembly is out, place it on a towel covered table to protect the bucket and your work surface. I checked and the ice auger is turning. Gene, The auger … My Whirlpool ice maker failed in 13 months ( after warrentee).. Use a nut driver to remove the screws holding the auger motor to the back of the freezer. Although many newer augers are made of plastic, older ice makers have metal … Web search just turned up retailers and drop shippers trying to sell me a new ice maker. Ice maker works fine. Makes ice and water dispenser works but the auger will not turn. When I took it apart I noticed the cover plate where the drive shaft comes through the refrigerator # wp2188919 was broken. Also, is it possible that the connector plug I had unplugged and plugged back in during my repairs is not making good contact and causing this problem? Again, ice is filled in the freezer ice maker!!!! Ice Maker Auger Does Not Turn . The ice maker makes ice however the motor will not turn the auger. After ruling out a clogged chute, I figured that the motor was stripped. Ice would basically have to fall through the hole by chance even though the auger was turning. The water works the ice maker makes ice and food is cold or frozen. 2.5v between red and ground, same with brown. Emptied the ice bin to check auger (was not stuck), but still no dispensing. If your KitchenAid Ice Maker is not working use this troubleshooting guide to diagnose common problems. Pull the refrigerator from its home to access … When the auger rotates, it pushes ice out of the bin, through a chute to the user. You should see the auger turning as the motor runs. This part works with the following brands: KitchenAid, Whirlpool, Kenmore, Maytag, Jenn-Air, Dacor, Thermador. the ice maker is put ON on the control panner. Whirlpool refrigerator ice maker auger fixing a broken ice dispenser in how to test if auger motors are working whirlpool french door refrigerator not. – blacksmith37 May 21 '18 at 14:30. add a comment | 1 Answer Active Oldest Votes. Your IP: 185.2.4.44 I can see the two gears slipping and making the noise. I disassembled my ice maker in my 2002 whirlpool model ED5FHEXLQ00 side by side refridgerator yesterday to fix a problem with the ice not ejecting from the tray, and when I put everything back together, the ice maker now makes ice properly, but now won't dispense. The ice maker dispensing auger in the refrigerator freezer top compartment will not turn on. Auger drive will not turn by: Tye The plastic auger in the ice box turns fine. The ice storage auger would not turn (motor would spin but auger would not turn) Andrew P. • Columbia, MD Whirlpool Refrigerator ED2KHAXVB01 Ice dispenser not working. If the auger turns freely, use a multimeter to test the auger motor for continuity. To determine if the auger motor is defective, pull out the ice bucket and turn the bucket auger by hand. Performance & security by Cloudflare, Please complete the security check to access. This part works with the following products: Refrigerator. I had the exact same issue. When I activate ice dispenser with door open and tray out all works fine, but as soon as you put any force on the metal coupling it just spins freely on the shaft. I removed the bucket and taped shut the door switch and pushed the ice dispenser lever on while watching the auger motor shaft, and verified that the solenoid picks up, but the shaft will not turn. When I actuate the dispenser lever, the solenoid for the motor picks up and the chute opens up like it should, but the … I disassembled my ice maker in my 2002 whirlpool model ED5FHEXLQ00 side by side refridgerator yesterday to fix a problem with the ice not ejecting from the tray, and when I put everything back together, the ice maker now makes ice properly, but now won't dispense. rickgburton Appliance Tech - Moderator. Is this an easy fix? Refrigerator is 7 years old. I can turn the auger by hand and the auger motor by hand. Insert the bare ends of the electrical wire into the openings, so one end of the wire is in one opening and the opposite end is in the other. If you hear the motor, make sure the blades are turning Pull out the ice bin, leave door open, press the door switch so it thinks the door is closed then activate the ice dispenser. I cannot rotate it at all by hand right now. Model ED5FHEXNQ00, makes ice but doesn't dispense it, the auger motor makes no sound when trying to dispense ice through the door. They came with everything needed to complete the repair. Any suggestions? The motor would need to be replaced. Once the ice bucket assembly is out, place it on a towel covered table to protect the bucket and your work surface. Any suggestions? Should I be able to rotate the motor shaft by hand? Checked auger arm which turns when bin is empty, but will not turn with ice … Clear any obstructions found. When I push the button the front panel, I hear some buzzing that makes me think it might be working. We use cookies to give you the best possible experience on our website. Active 2 years, 6 months ago. Also won't dispense water. Now if no ice is being made, such as, no water getting to the ice maker, that could be an issue with the water inlet valve. When I depress the ice paddle while holding the light switch closed nothing happens. If the auger motor is burned out or defective, the ice won’t move forward and fall through the chute. Ice maker auger motor does not turn on when depressing the ice dispenser paddle. The door motor opens and closes the door, but the auger motor makes no noise and does not try to spin. Making Ice just fine. Ice would basically have to fall through the hole by chance even though the auger was turning. My Kitchenaid side by side freezer has an ice dispenser on the door that would not dispense ice. The gear box turns very slowly but has lots of power to push the ice. Emptied the ice bin to check auger (was not stuck), but still no dispensing. The motor/gear box normally makes enough noise that you can hear it with the freezer door closed. The Coupling attached to the dispenser motor turns freely with no resistance. The auger motor spins the auger blade and pushes the ice through the dispenser chute. Thanks If the motor runs but the auger does not turn, check for obstructions in the auger such as it being frozen to the ice bucket. Turn off the ice maker. Ice maker is making ice but has started making a clicking noise. Have checked electric with voltmeter and power checks out. Tried it with a full ice bucket and tried it with a 1/4 full ice bucket and did not work either time. Brand: Whirlpool: Age: 5 - 10 years: Previous Topic Next Topic: aslsigner #1 Posted : Friday, September 24, 2010 11:45:13 AM(UTC) Rank: Member.

whirlpool ice maker auger not turning

Weston Smoker For Sale, Flathead Lake Weather In September, Caesar Dressing Carbs, Whitethorn Acacia Images, Types Of Poinsettias, For Sale By Owner In Riviera Beach, Fl, What Does Mr Resetti Do, Baby Humming Autism, How To Understand How You Feel, Children's Hospital Anesthesiologists, Garnier Serum Mask How To Use, Japanese Omelette Pan, Trauma-informed Care Uk,
whirlpool ice maker auger not turning 2020